Install Drain Concrete Floor

A square garage floor drain these also come round is a simple very easy to install floor drain.

Install drain concrete floor.

They are very inexpensive and much faster easier to put in place. If you are not then you will have to pour a new floor over the existing one and pitch the new floor to the drain. Hopefully you are installing the drain where there is a low spot in your existing concrete floor. We install twice as many of these concrete floor drains versus the trench drains.

After the forms have been set for the new drain system in the floor pour new concrete and allow it to dry. For a stable floor floors and studs must be at the right angle. Pour the new concrete at the end of the pipe where you want the actual floor drain to be located place a can a coffee can will work over the drain hole and pour new concrete to fill in the trench you dug. While it s easiest to install a floor drain prior to pouring your cement you can do it after the floor has been set.

The pvc paper that was laid down should extend 2 inches above the surface and the height of the shower base. Fit the flange over the pipe to place it flat against the concrete floor. Bell trap drains come in 6 8 and 12 inch square or round shapes. Leave about 4 to fill the trench with new concrete.

Decide what kind of materials you will have entering the drain and if you need and special permits for hazardous materials. Run a drainpipe under the concrete floor shower stall on concrete a shower usually requires a 2 in. Retrofit a floor with a floor drain by using a hammer and chisel to break away the concrete to form the drain trenches. For the drain to function optimally the slab must slope toward the drain to direct water to the.

Mix the concrete according the the mixing directions and smooth out with a trowel. Cover the pipe with the dirt you dug out and use a hand tamper to compact it. If you want to install a shower over a concrete floor a fiberglass shower stall will work just fine. This should be left on the subfloor.

Leave a 5 5 opening for the drain. This is basically a durable plastic ring which fits over the drainage pipe to create a place where the toilet can gain solid purchase. Be sure to remove enough concrete from the area just before the drain pipe to fit a drain trap in line. Despite how it may seem it s actually relatively easy to retrofit a drainage system especially with the right system.

If you will have just water entering the drain you can connect it to your sewer or septic system. Installing a floor drain in a garage s concrete slab floor is best done when pouring the slab.